Starlane Digital Dashboard - Common Fault and how to Repair - MVAgusta.net
 
LinkBack Thread Tools Display Modes
post #1 of 4 (permalink) Old 06-12-2016, 02:01 AM Thread Starter
Senior Member
 
squibby's Avatar
 
Join Date: Jul 2009
Location: Newcastle NSW
Posts: 786
Starlane Digital Dashboard - Common Fault and how to Repair

I thought I'd post this repair on the forum. Reason being, the Starlane Products, Digital Dashboards etc are compatable with MV Agusta and I've got one for mine. I'd like this thread to be here on the forum so that users of Starlane products will find it when searching google because the fault I had on mine is Guranteed to fail for everyone who has the Starlane Xenon, and possible it's successors. Suprising that such an expensive product is by design going to fail within about 10 years. So here is how to fix it...

I bought a faulty Starlane Xenon Dashboard and the problem is that the internal memory forgets everything when the ignition switched supply is turned off. This is a problem, it reboots and needs to be reloaded with your specific settings all over again rendering useless. I suspected there would be a capacitor or battery, maybe rechargeable that maintains the internal memory when the ignition is off, and that it has failed with time.

When I opened it up, I was not impressed to find a non-rechargeable CR2025 battery embedded in there hiding under some insulation tape. It is by design not supposed to be replaced, and you have to damage a few solders and reduce the resistance to vibration to fix this unfortunately... So you will probably need one of these. Buy a lithium CR2025 it should last up to 10 years.

You will need a few tools, T10 Torx bit, Knife, insulation tape, and a few other bits and pieces. Undo the four torx bits on the back, two are covered by warranty stickers. Then pry the case open, it's stiff because it's sealed with silicone. Remove the circuit board and on the back you will see a CR2025 soldered and silicone in place. Cut the silicone and pry the solder out. Tricky and be careful. Try not to short the two sides of the battery with the knife. Once you have ripped the old batter out, use insulated tape to stick the new one firmly in place. You need to know what you are doing and have a steady hand.

Re-assemble, and voila, good for another 10 years hopefully.

Apparently Starlane are not the only guys who do this, most handheld electronics have the same principles. Non-replaceable 10 year battery embedded into them so they are basically 100% guaranteed to be useless junk after about 10 years unless they get some attention.
Attached Images
       

Last edited by squibby; 06-22-2016 at 05:02 PM.
squibby is offline  
The Following User Says Thank You to squibby For This Useful Post:
Sponsored Links
Advertisement
 
post #2 of 4 (permalink) Old 06-12-2016, 02:16 AM
Moderator
 
Donsy's Avatar
 
Join Date: Aug 2008
Location: Australia
Posts: 22,055
New Site Garage
Thumbs up

Thanks for that mate, I've always wanted one of those but never been able to afford one, but I know there are a few guys on the forum who have these and would appreciate the info.

PS. Would it be possible to use plastic weld to re-install instead of the insulation tape ?

Dons Nel
Own - Two F4 1000R's 06 and 07.
PayPal :
To view links or images in signatures your post count must be 10 or greater. You currently have 0 posts.

eMial:
To view links or images in signatures your post count must be 10 or greater. You currently have 0 posts.

Mobile in Australia: 0438 385 776
Website with MV Manuals for Most models -
To view links or images in signatures your post count must be 10 or greater. You currently have 0 posts.
Donsy is offline  
post #3 of 4 (permalink) Old 06-12-2016, 03:37 AM Thread Starter
Senior Member
 
squibby's Avatar
 
Join Date: Jul 2009
Location: Newcastle NSW
Posts: 786
Yes, that would be fine. But insulation tape is required over the top of the battery as it may come into contact with tye inside of the case. See how they did that on the original battery, they used insulation tape.
squibby is offline  
Sponsored Links
Advertisement
 
post #4 of 4 (permalink) Old 06-13-2016, 08:46 PM Thread Starter
Senior Member
 
squibby's Avatar
 
Join Date: Jul 2009
Location: Newcastle NSW
Posts: 786
You can get Starlane to do it for 50 Euro plus shipping. In fact their after sales support has been pretty good.

Last edited by squibby; 06-19-2016 at 04:37 PM.
squibby is offline  
Reply

Quick Reply
Message:
Options

Register Now



In order to use all of the features of the MVAgusta.net site, you must first register.
Please enter your desired user name, your email address and other required details in the form below.

User Name:
Password
Please enter a password for your user account. Note that passwords are case-sensitive.

Password:


Confirm Password:
Email Address
Please enter a valid email address for yourself.

Email Address:
OR

Log-in










Thread Tools
Show Printable Version Show Printable Version
Email this Page Email this Page
Display Modes
Linear Mode Linear Mode



Posting Rules  
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are On
Pingbacks are On
Refbacks are On

 
For the best viewing experience please update your browser to Google Chrome